Thanks: 0
Likes: 0
Results 1 to 10 of 18
Thread: Johnson outboard bogs down
Hybrid View
-
07-20-2021, 02:11 PM #1
Johnson outboard bogs down
Got an old 89 60 hp Johnson vro that runs great for 4 or 5 trips and then out of no where bogs down like it's not getting gas if I give it throttle. Took me an hour and a half to get from Cedar point area to East harbor. I thought it might have been the fuel pump but put a new one in and it did the same thing. The oil sender was removed years ago so I pre mix the gas. Tried turning it off and priming the engine but bulb was soft and won't prime not sure if that's normal. Wake up the next day and bulb is hard and it will run like a charm 4 or more trips. Can't figure it out. Anybody got any thoughts besides buying a new boat. Just don't have the cash flow.
Last edited by badboards; 07-20-2021 at 02:16 PM.
-
07-20-2021, 02:38 PM #2
Re: Johnson outboard bogs down
Them engines have a diaphragm style fuel pump I believe. This would be on the engine side of the primer bulb. If the rubber diaphragm starts to degrade this can cause fuel deliver problems that act much like an air leak. Ethanol is rough on these types of things. Also it is very rough on a 2 stroke engine to run it while it is lean such as in the problem you are describing. Kent
-
07-20-2021, 04:02 PM #3
Re: Johnson outboard bogs down
I hated running it that far like that but at 6 miles per hour it runs fine when it's doing that. As for the fuel pump it's an after market pump and yes they do that but the new pump did the same thing. They don't make the OEM anymore.
-
07-20-2021, 04:54 PM #4
Re: Johnson outboard bogs down
Did you check the vent on your fuel tank and make sure it’s operating properly?
-
07-21-2021, 10:26 AM #5
Re: Johnson outboard bogs down
Mark at Outboard Motor Service is who you are referring to. Call him and let him know whats going on. If you get there during the week, or on Friday, he can usually have things diagnosed to let you know how to proceed. Mark only works on Johnson Evinrude brands.
Also, Lee's Outboard Motor Service, (419) 734-1115 is also in PC. Lee used to work for Mark and knows those engines well too. He also is certified for Yamis and Mercs if I remember. I trust both of them with my engines a 200hp and a 115hp on another boat.
I would replace all fuel lines and bulb, emply water filter and replace that filter if not new this year first. Then you can pinpoint if a tank issue, or motor issue. If you have been running gas with ethanol, those lines might give you 7 years or so before they are Chit. I don't run ethanol in my boats any longer.
Rickerd
-
07-20-2021, 05:18 PM #6
Re: Johnson outboard bogs down
I haven't checked the vent but I did open the gas filler cap and it didn't change anything.
-
07-20-2021, 05:53 PM #7Senior Member
- Join Date
- Jun 2008
- Location
- columbus ohio
- Posts
- 368
- Post Thanks / Like
- Blog Entries
- 1
Re: Johnson outboard bogs down
Hello Badboards I wonder if you have a hose that is going bad from the inside and that is blocking the fuel the symptom of the bulb going soft till next morning then gets hard may be that its not able to pull any fuel out of tank or a pin hole in the line between the bulb and the tank will suck air and cause the pump to loose its prime , just a thought .
-
07-20-2021, 06:50 PM #8
Re: Johnson outboard bogs down
Yes I believe you could be on to something there maybe it is a line going bad also I have a fuel filter before the engine that's clear not sure if this is normal or not but when I pump the bulb I see air bubbles in the filter. Not sure if that's normal.
-
07-21-2021, 01:08 PM #9Senior Member
- Join Date
- Jun 2008
- Location
- columbus ohio
- Posts
- 368
- Post Thanks / Like
- Blog Entries
- 1
-
07-21-2021, 01:19 PM #10Senior Member
- Join Date
- Jun 2008
- Location
- columbus ohio
- Posts
- 368
- Post Thanks / Like
- Blog Entries
- 1
Re: Johnson outboard bogs down
I should be up at my dock sometime Thursday after noon working on my boat if your in the area I can take a look at it if you want
Similar Threads
-
1988 Grady White 19.6 Tournament DC. 2000 175 Johnson
By Walleye.com in forum Fishing Boats FOR SALE (Latest Listings)Replies: 0Last Post: 05-02-2019, 07:55 PM -
Fishing with Bob and LeAnn Johnson 4/15/15
By Capt Juls in forum Western Lake Erie Fishing REPORTSReplies: 1Last Post: 04-15-2015, 08:20 PM -
Fishing with the Johnson's 5/23/14
By Capt Juls in forum Western Lake Erie Fishing REPORTSReplies: 3Last Post: 05-25-2014, 08:32 PM -
1956 jOHNSON 10 hP
By POPEYE in forum Boats & MotorsReplies: 3Last Post: 05-25-2013, 01:17 PM -
Johnson Engine mechanic near Sandusky?
By rsdata in forum Boats & MotorsReplies: 1Last Post: 05-11-2013, 02:13 AM
I've had my boat infested with...
Midges. What to do?